鎮江INA軸承能自動補償軸承的硬性偏差和軸承中點的中點線，從而保證軸承的異常狀態。

Zhenjiang INA bearing can automatically compensate for the hardness of the bearing deviation and bearing midpoint line, thus ensuring the abnormal state of the bearing.

由于軸承座孔的偏離、軸的加工和安裝、以及后軸在載荷作用下的彎曲變形，在任何情況下都不可能使軸與內外環重疊。軸的撓度將導致軸承外側的應力分布不均勻。軸承的后期成形將起到一定的作用。因此，像往常一樣，即使需要漸進的裝置方案，對于具有大繞組變形的零件，也應選擇具有良好對準的軸承。

It is impossible to overlap the shaft with the inner and outer rings under any circumstances due to the deviation of the bearing seat hole, the machining and installation of the shaft, and the bending deformation of the rear shaft under the action of load. The deflection of the shaft will cause uneven distribution of stress on the outside of the bearing. The later forming of bearings will play a certain role. Therefore, as usual, even if a gradual device scheme is required, bearings with good alignment should be selected for parts with large winding deformation.

首先，堅持鎮江INA軸承及其周?chē)h(huán)境的清潔，即使進入軸承的微小無形灰塵，也會增加軸承的磨損、振動和音樂。

First of all, adhere to the Zhenjiang INA bearing and its surrounding environment clean, even into the bearing of the tiny invisible dust, will increase bearing wear, vibration and music.

其次，要小心使用該設備，以便沖壓力強，不允許錘子間接突破軸承，不允許相對敏銳的壓力。

Secondly, the device should be used with care so that the stamping force is strong, the hammer is not allowed to break through the bearing indirectly, and relatively sensitive pressure is not allowed.

第三，即使不使用布料和短纖維，也可以使用適當和精度性的設備對象來應用不相關的對象。

Third, even if cloth and staple fibers are not used, appropriate and accurate device objects can be used to apply unrelated objects.

第四，為了防止鎮江INA軸承的腐蝕，須及時用足夠的汗水清洗軸承，然后高品質的礦物油在旱季和夏季油漆作業中應特別注意防銹。然而，在一些特殊情況下，軸承可以更好地用于傳統的計算，特別是在輕載條件下。這些不相關的操作的前提是，當旋轉表面（軌道和旋轉部件）是用于分離和定義污染物的有用的光滑膜時，會發生外部損傷。

Fourth, in order to prevent the corrosion of Zhenjiang INA bearings, it is necessary to wash the bearings with enough sweat in time, and then high-quality mineral oil in dry season and summer paint operations should pay special attention to rust prevention. However, in some special cases, bearings can be better used for traditional calculations, especially under light load conditions. The premise of these unrelated operations is that external damage occurs when the rotating surface (orbits and rotating parts) is a useful smooth membrane for separating and defining pollutants.

軸承的清潔度對向心推力球鎮江INA軸承的使用壽命有很大的影響。結果，差異是幾倍甚至幾十倍。向心推力球軸承越清潔，其余實驗的壽命就越長：不同清潔度的光滑油對球軸承的壽命有很大的影響。因此，改進后的潤滑油的清潔度可延長向心推力球軸承的使用壽命。另外，向心推力球軸承的壽命是否穩定，油粒是否會乘以10米？

The cleanliness of the bearing has great influence on the service life of the centripetal thrust ball Zhenjiang INA bearing. As a result, the difference is several times or even dozens of times. The cleaner the centripetal thrust ball bearing, the longer the life of the rest of the experiments: different cleanliness of the smooth oil has a great impact on the life of the ball bearing. Therefore, the cleanliness of the improved lubricating oil can extend the service life of the centripetal thrust ball bearings. In addition, whether the life of the centripetal thrust ball bearing is stable and whether the oil particles will be multiplied by 10 meters?

(1)清潔度對振動的影響嚴重影響向心推力球鎮江INA軸承的振動程度，尤其是高頻振動。Gao Jie軸承的振動頻率較低，尤其是在高頻段。

(1) The influence of cleanliness on vibration seriously affects the vibration degree of Zhenjiang INA bearing with centripetal thrust, especially the high frequency vibration. The vibration frequency of Gao Jie bearing is low, especially in the high frequency section.

（2）研究了粉塵對徑向推力球潤滑脂噪聲的影響。結果表明，粉塵越多，噪聲越大。

(2) the effect of dust on the noise of radial thrust ball grease was studied. The results showed that the more dust, the greater the noise.

文章來自：鎮江SKF軸承 www.wh-skf.com

The article is from: Zhenjiang SKF bearing www.wh-skf.com

文章來自：鎮江INA軸承 www.ina-china.cn

The article is from: Zhenjiang INA bearing www.ina-china.cn

文章來自：鎮江NSK軸承 www.klbbearings.com

The article is from: Zhenjiang NSK bearing www.klbbearings.com

QQ：524085168

電話：0510-81207777

手機：13311666672